The use of generator sets in harsh environmental conditions is mainly due to the influence of environmental factors. Some measures and methods that must be adopted for operation in high-altitude plateau areas and in extreme cold weather conditions are as follows. The following is a comprehensive introduction to the usage methods in various special environments:

一高海拔的高原地區的使用
發電機組配套的發動機，特別是自然進氣式發動機當在高原地區使用時，由于空氣稀薄不能象在海平面高度那樣燃燒那么多的燃料而損失一些功率，對于自然進氣的發動機，一般海拔每升高300m功率損失約3％，因此在高原的確工作時，應使用較低的功率以防止冒煙和燃氣消耗過多。

The use of engines equipped with generator sets in high-altitude areas, especially naturally aspirated engines, results in some power loss due to the thin air that cannot burn as much fuel as at sea level. For naturally aspirated engines, the power loss is generally about 3% for every 300m increase in altitude. Therefore, when working in high-altitude areas, Lower power should be used to prevent smoke and excessive gas consumption.

二在極端寒冷氣候條件下作業

Working in extreme cold weather conditions

增用輔助啟動設備（機油加熱器水套加熱器等）

Add auxiliary starting equipment (oil heater, water jacket heater, etc.)

利用電加熱器，將冷態發動機的冷卻水潤滑油加熱，使整個發動機升溫，以便能順利地起動。
當機房溫度低于4°C時，安裝冷卻液加熱器使發動機缸體維持溫度在32°C以上。

Using an electric heater, heat the cooling water and lubricating oil of the cold engine to raise the temperature of the entire engine for smooth starting< When the temperature in the engine room is below 4 ° C, install a coolant heater to maintain the temperature of the engine block above 32 ° C.

（1）安裝發電機組低溫報警器。

(1) Install the generator set low temperature alarm.

對于會降至－18°以下環境溫度下工作的發電機組，還需要潤滑油加熱器，以防止?jié)櫥凸袒?。機油加熱器安裝在發動機機油盤上。它加熱機油盤內的機油，便于發動機在低溫下起動。

For generator sets that operate in ambient temperatures below -18 ° C, a lubricating oil heater is also required to prevent the lubricating oil from solidifying. The oil heater is installed on the engine oil pan. It heats the oil in the oil pan, making it easier for the engine to start at low temperatures.

（2）采用低溫潤滑油

(2) Using low-temperature lubricating oil

使用低溫潤滑油，降低潤滑油粘度，以提高潤滑油的流動性和減少液體的內部摩擦阻力。

Use low-temperature lubricating oil to reduce its viscosity, improve the fluidity of the lubricating oil, and reduce the internal friction resistance of the liquid.

（3）利用高能蓄電池

(3) Utilizing high-energy batteries

采用高能量蓄電池，如目前的鎳氫電池及鎳鎘電池等。注意對蓄電池的加熱或加熱保溫，若機房溫度會降至0℃以下，應裝備蓄電池加熱器。以保持蓄電池的容量和輸出功率。

Using high-energy batteries, such as current nickel hydrogen batteries and nickel cadmium batteries. Pay attention to heating or insulation of the battery. If the temperature in the computer room drops below 0 ℃, a battery heater should be equipped. To maintain the capacity and output power of the battery.

三對于發電機組工作在高潮濕的場合，發電機繞組和控制箱應安裝加熱器，以防止發電機繞組和控制箱內部由于冷凝而造成短路或破壞絕緣。

For generator sets operating in high and humid conditions, heaters should be installed in the generator winding and control box to prevent short circuits or insulation damage caused by condensation inside the generator winding and control box.

注意：對于不同用途和型號的發動機，由于對它的低溫起動性能的要求不同，所采用的低溫起動措施也不同。對于低溫起動性能要求高的發動機，為保證其在很低的溫度下能順利起動，有時需要同時采用多種措施：

Note: For engines with different purposes and models, the low-temperature starting measures adopted vary due to the different requirements for their low-temperature starting performance. For engines with high requirements for low-temperature starting performance, in order to ensure smooth starting at very low temperatures, it is sometimes necessary to take multiple measures simultaneously:

乙醚輔助啟動

Ether assisted start

四在清潔度差的條件下作業

Working under poor cleanliness conditions

在臟污的環境和多塵的環境下長期運轉會損壞零部件。堆積的污泥臟物和塵土可能會包裹著零部件，會使保養更困難。堆積物會含有腐蝕性化合物和鹽類，會損壞零部件。因此為大程度保持長的使用壽命必須縮短保養周期。

Long term operation in dirty and dusty environments can damage components. The accumulated sludge, dirt, and dust may wrap around the components, making maintenance more difficult. Accumulation can contain corrosive compounds and salts, which can damage components. Therefore, in order to maintain the longest service life to the greatest extent possible, it is necessary to shorten the maintenance cycle.

五燃氣發電機組其他地理環境下的使用

5. Use of Gas Generator Units in Other Geographical Environments

燃氣發電機除了在企事業單位中貢獻突出，但是在其它特殊環境中使用更有其特殊作用與意義。

Gas generators not only make outstanding contributions in enterprises and institutions, but also have a special role and significance when used in other special environments.

開發邊疆地區的電力供應

Developing electricity supply in border areas

我國的邊遠地區都有著豐富的資源，但有的遠離供電網絡，而現代技術開發又都毫無例外地要有充足的電力供應。燃氣發電機設備便是能迅速滿足這一要求的好選擇，因為它投資省建成快，可自成網絡供電，所以近年來許多國家邊遠地區開發都大量采用燃氣發電機。

The remote areas of our country have abundant resources, but some are far from the power supply network, and modern technology development without exception requires sufficient power supply. Gas generator equipment is the best choice to quickly meet this requirement, as it is easy to invest and can be built quickly, and can form its own network for power supply. Therefore, in recent years, many countries have extensively adopted gas generators in the development of remote areas.

滿足沙漠地區用電需求

Meeting the electricity demand in desert areas

為了滿足沙漠腹地石油天然氣勘探和開發需要，燃氣發電機組在沙漠地區的使用將伴隨沙漠開發而大大增加。

In order to meet the needs of oil and gas exploration and development in the hinterland of the desert, the use of gas generator sets in desert areas will greatly increase with desert development.